Heap Bioleaching of Low-grade Multimetal Sulphidic Ore in Boreal Conditions
|Kustantaja||Tampere University of Technology|
|Tila||Julkaistu - 27 marraskuuta 2015|
|Nimi||Tampere University of Technology. Publication|
|Kustantaja||Tampere University of Technology|
The experiments were carried out using laboratory-scale columns containing about 9 kg of agglomerated ore. The columns were loaded with the ore, irrigated with pregnant leaching solution (PLS) by recycling and aerated from the bottom. The tested pH range was from 1.5 to 3.0 at 21 ºC and temperature range was from 7 to 50 ºC at pH 2.5. The particle size (d80) of the ore was 7.6 mm. Surface water taken from lake near the Sotkamo deposit (slightly affected by acid mine drainage) supplemented with nutrients was used for irrigation. Aeration was provided through a diffuser inserted at the base of the column. The iron- and sulphur-oxidizing bacterial culture used in inoculation of the columns, was enriched from surface water samples (pH 4.5-6.9) obtained from the ore deposit. The pH of irrigation solution was maintained with continuous titration with H2SO4. The ore was acid consuming in all tested conditions. The actual pH of the irrigation solutions after 140 days were 0.1-0.5 units over the target values in all columns. Leaching at low pH resulted in increased acid consumption of 160 and 38 H2SO4 g kg-1 ore at pH 1.5 and 2.0 after 140 days. Temperature, at pH 2.5, had also effect on acid consumption. At 50 ºC acid consumption was highest and lowest at 21 ºC, being 29 and 8 H2SO4 g kg-1 ore, respectively.
The pH of the irrigation solution clearly affected to the dissolution of nickel and zinc. Nickel solubilization rate was 3.3 times higher at pH 1.5 than at pH 3.0, being 0.42 and 0.13 % (Ni) d-1, respectively. At pH 1.5 valuable metals yields were 59 % for Ni, 52 % for Zn, 13 % for Cu and 16 % for Co, whereas at pH 3.0 yields were 15 % for Ni, 10 % for Zn, 0.5 % for Cu and 6 % for Co after 140 days of bioleaching. No significant bioleaching happened after that at pH 1.5, 2.5 or 3.0. At pH 2.0 the maximum yields were achieved after 230 days of bioleaching. Nickel and zinc leaching rates and yields decreased nearly linearly as pH increased. Copper did not bioleach at high pH (2.5-3.0). After the beginning, no further cobolt dissolution happened at pH 3.0. Decrease in leaching rates may be due to a lack of dissolved ferric iron, serving as a leaching agent, or metal dissolution barriers created by precipitates on the ore surfaces. The ferric iron concentration in PLS increased all the time at pH 1.5, being 36 g l-1 after 140 days. At pH 2.0 the ferric iron concentrations varied, being highest 3.8 g l-1 after 97 days. At 2.5 and 3.0 no ferric iron was present in PLS and iron concentration remained low, being 15 mg l-1.
After 60 days of bioleaching the leach liquor at pH 1.5 became jelly-like due to solubilization of Si from the ore, which contained 42 % (w w-1) of SiO2. Quartz, phlogopite, and feldspars (anorthite and microcline) were the main Si-containing phases. After 110 days the Si concentration reached 2.96 g L-1 at pH 1.5. Soluble Si increases the solution viscosity and thus hinders leach liquor percolation trough the heap, lowers the oxygen transfer rate, and complicates subsequent metal extraction. Although, dissolved Si did not affect the solubilization of valuable metals, the pH value of the PLS must be kept at over 1.5 to slow down Si-containing mineral dissolution. At pH 2.5 less than 200 mg L-1 Si was solubilized and different temperatures had no effect on Si dissolution at that pH.
Based on an optimisation between the maximum valuable metal yields, leaching rates, the acid consumption, and the low dissolution of cations (Si, Al, Ca, Mg and Mn), the leaching solution pH of 2.0 was recommended for a bioheap application. At pH 2.0, the maximum leaching yields were achieved after 230 days, being 54 % for Ni, 37 % for Zn, 13 % for Cu and 12 % for Co.
Temperature strongly affected the valuable metal yields at pH 2.5. Leaching at low temperature (7 ºC) resulted in yields of 24 % for Ni, 17 % for Zn, 2 % for Cu and 6 % for Co after 496 days. The Cu leaching increased all the time during the experiment at 7 ºC, while at other temperatures it slowed down after 100 days. The highest yields were obtained at 21 ºC (26 % for Ni, 18 % for Zn, 0.5 % for Cu and 6 % for Co) after 153 days. After re-inoculation (day 65) with a thermophilic Sulfolobus culture, leaching at 50 ºC accelerated but slowed down soon and resulted in 18 % for Ni, 11 for Zn, 0.3% for Cu and 2% for Co (after 140 days). In the column leaching study, after the maximum yields, longer leaching time did not result more metals in solutions.
The redox increased during the first two months at 7 ºC and reflected the start of ferrous iron oxidation and microbial activity. The concentration of ferric iron was around 400 mg L-1 after two months. After that ferric iron was present all the time at 7 ºC and this demonstrated that more ferric iron was available for the oxidation of the mineral sulphide than at other temperatures. The leach liquor redox potential stabilized to 500-600 mV (Ag0/AgCl reference) at 7 ºC after 40 days and at 21 ºC right after beginning, whereas at 35 ºC and at 50 ºC it varied between 300-500 mV. At 50 ºC, all dissolved iron was in ferrous form inspite the variation of redox. After 50 days Fe2+ and Fetot were both 350 mg L-1 indicating that iron oxidation and precipitation occurred at the same time. Brown precipitates accumulated to the surfaces of the agglomerated ore in columns from 7 ºC to 50 ºC. Additionally, bright yellow precipitates were formed indicating elemental sulphur or Na-jarosite accumulation at 7 ºC and 21 ºC.
After 50 days of bioleaching, at 7 ºC leach liquor total cell counts (108-109 cells mL-1) were significantly higher than at other temperatures (106-107 cells mL-1). Cell counts remained that high troughout the column study. At the end of the experiment, total cell counts in the leach residues were studied. At 7, 21, 35 and 50 ºC cell counts of the leach residues were 3.4· 108, 2.3· 108, 1.1· 107 and 8.7· 106 cells ore g-1, respectively. The pH did not affect at 21 ºC the numbers of microorganisms in the PLS and cell counts remained at 106-108 cell mL-1 throughout the study and the leach residues contained about 108 cells g ore-1.
The microbial community composition and dynamics was by investigated by DNA extraction PCR-DGGE-sequencing approach. The microbial community were not affected by pH. In contrast, temperature affected the microbial populations. After the first months, Acidithiobacillus ferrooxidans AP 310 (96-99% sequence similarity, accession DQ35518) was the only species detected at 7 ºC and was also present at other temperatures. After the data of this study was published (2007), two new Acidithiobacillus species were described, A. ferrivorans and A. ferridurans. Genetically these species are very near each other. The 16S rRNA gene sequences of the bands that corresponded 99% of A. ferrooxidans AP310 (DQ35518) were identified again in 2015 using the basic local alignment search tool (BLAST). The 16S rRNA gene sequences of A. ferrooxidans at temperatures of 7 and 21 ºC corresponded 99% as A. ferrivorans SS3 (CP002985). One of the 16S rRNA gene sequences of A. ferroxidans strains at 35 ºC corresponded 99% as A. ferridurans ATCC 3302 (NR_117036). At 50 ºC, no proper A. ferroxidans 16S rRNA gene sequences were gained with the used methods. The presence of A. ferroxidans at 50 ºC was concluded based on the fact that the DGGE band was in the same place as the other A. ferrooxidans bands. The 16S rRNA gene sequences of Acidithiobacillus ferrooxidans strains in pH between 1.5 and 3.0, at 21 ºC, corresponded also 99% as A. ferrivorans SS3 (CP002985). In the light of increased knowledge, these species cannot be separated with the denaturing gradient from 40 to 70% that were used in the DGGE. A. ferrooxidans, A. ferrivorans and A. ferridurans are able to oxidize both iron and sulphur compounds.
Leptospirillum ferrooxidans DSM 2705 (98-100%, X86776) and Sulfobacillus thermotolerans KR-1 (99%, DQ124681) were mainly detected at 21 ºC and 35 ºC. Sb. thermotolerans was present at 50 ºC. L. ferriphilum D1 (99 %, DQ665909) appeared after 300 days of bioleaching and was present in every leach residue, except at 7 ºC and pH 3.0. L. ferrooxidans and L. ferriphilum are able to oxidize only iron. Sb. thermotolerans is able to oxidize both iron and sulphur compounds.
Archaeal species were analyzed two times from leach liquors and three species were detected. A species related to an uncultured archaeon clone ant b7 (99%, DQ303249), nearest known species Thermoplasma acidiphilum DSM1728 (91%, AL445067) was present in all of the leach liquors except at pH 1.5. Archaea related to Sulfolobus metallicus DSM 6482 (98%, SM16SRRN1) were present at pH values 2.5 and 3.0 and in all other temperatures, except at 7 ºC. Sulfolobus metallicus is able to oxidize both iron and sulphur compounds. Ferroplasma acidiphilum DR1 (98%, AY222042) that can oxidize only iron, was present at pH 2.5 and 2.0, and in all temperatures, expect at 35 ºC.
The mixed iron- and sulphur-oxidizing culture in the recirculation solution at 7 ºC was used in the experiments where Fe2+-oxidation rate and optimum temperature were determined over a temperature range of 2-40 ºC. Two temperature optima of 22.4 ºC and 32.4 ºC were observed. This indicated the presence of both psychrotolerant and/ or mesophilic microorganisms in the culture. This supports the suggestion that A. ferrooxidans was actually A. ferrivorans, or both species were present. The specific oxidation rates for the culture were similar, with 13.5·10-8 and 12.8·10-8 mg Fe2+ cell-1 h-1 for 22.4 ºC and 32.4 ºC, respectively.
The two demonstration-scale bioheaps (17 000 t) at the Talvivaara mine site were operated and monitored by Talvivaara Mining Company for 30 months. After the start-up of heap irrigation, oxidation of pyrrhotite and pyrite increased the heap temperature in central locations up to 90 ºC. In the second winter temperatures inside the heaps decreased being still 80 ºC at the hottest spots. Leach liquor temperatures varied between 60 ºC and 15 ºC over the whole operation period. The target pH of the PLS was 2.0. Inspite of continuous titration pH varied during the 10 months between 3.5 and 3.0 and after that between 3.0 and 2.5.
The bacterial community composition on the heaps was monitored over time from manholes and the leach liquor collection ponds. At the end of the primary bioleach phase (18 months) cell counts were around 106 cells mL-1. Large temperature gradients resulted in the simultaneous presence of mesophilic and thermophilic iron- and sulphur-oxidisers in the heap. In the beginning diversity was broad, but decreased with time. A. ferrooxidans/ ferrivorans SS3 (99%, CP002985) was the dominant bacterium and an unknown bacterium related to clone H70 (91%, DQ328625) was present. After six months of bioheap operation L. ferrooxidans DSM 2705 (98%, X86776) was observed for the first time and it was present thereafter in nearly all samples. Archaea were analysed during the primary leaching phase from leach liquors. Two novel archaea and one archaea related to Thermoplasma acidophilum strain 122-1B2 (91-93%, NR_028235) were detected.
Several ore samples were drilled from the primary bioheaps after one year of bioheap operation. A. ferrooxidans/ A. ferrivorans SS3 (99%, CP002985) was present in nearly all samples. The novel bacterium related to clone H70 (91%, DQ328625) and A. caldus related bacteria (95%, AY427958) was detected from the areas of wide temperature variation. Sb. thermosulfidooxidans strain YN22 (99%, DQ650351) was found from the high temperature zones of the heap. Ferrimicrobium acidiphilum T23 (99%, AF251436) was present in the areas where temperature varied between 20 and 35 ºC. After 18 months of demonstration-scale heap operation, the heaps were reclaimed and restacked to the secondary bioheap. At the secondary leaching phase the community remained steady. A. ferrooxidans/ ferrivorans SS3 (99%, CP002985) dominated and the novel bacterium related to a clone H70 (91%, DQ328625) and L. ferrooxidans DSM 2705 (98-100%, X86776) were present in the leach liquors of secondary phase bioheaps.